NIGERIAN JOURNAL OF SCIENCE AND ENVIRONMENT
Journal of the Faculties of Science and Agriculture, Delta State University, Abraka, Nigeria
ISSN: 1119-9008
DOI: 10.5987/UJ-NJSE
Email: njse@universityjournals.org
PRODUCTION OF ETHANOL FROM CASSAVA (Mannihot esculenta) WASTE WATER USING Saccharomyces cerevisiae and Escherichia coli
DOI: 10.5987/UJ-NJSE.17.111.3 | Article Number: E6830625 | Vol.10 (3) - December 2011
Author: Akponah E.
Keywords: Cassava, ethanol, fungal hydrolysis, heat hydrolysis, S. cerevisiae and E. coli.
The ethanol producing capabilities of axenic cultures of Saccharomyces cerevisiae and Escherichia coli from cassava waste water was investigated. Analysis of the initial composition of the substrate showed that it contained 71.97%, 1.2%, 0.5% and 23% (w/v) of starch, protein, fat and cyanide respectively. The cassava waste water pre-treatment approach for converting starch into reducing sugar involved inoculation of a consortium of indigenous amylolytic fungi (which include Geotrichum candidum, Aspergillus fumigatus and Aspergillus niger) and heating at 80oC for 30minutes which yielded 41.67% and 11.62% (w/v) glucose respectively. The glucose values decreased progressively with increasing duration of fermentation. At the end of fermentation period (7days), glucose levels recorded were 5.03% and 7.3% in amylolytic fungi pre-treated set-ups containing S. cerevisiae and E. coli respectively. In heat treated set-ups containing S. cerevisiae and E. coli, glucose levels at the end of fermentation were 1.01% and 1.82% (w/v) respectively. Also, the pH dropped with increasing duration of incubation such that pH values decreased from 4.48 to 4.1. A decrease in pH from 5.2 to 4.7 and 4.0 were observed in heat pre-treated set-ups containing S. cerevisiae and E. coli respectively while control pH dropped from 5.2 to 4.9. However,
ethanol produced seemed to be limited by fermentation duration. Highest yield were obtained after 72h of fermentation. Further increases in fermentation duration did not result in any significant yield in ethanol production. Also, fungal hydrolysis method resulted in higher yield in ethanol production than heat hydrolysis of cassava waste water. Maximum ethanol produced were 13.33% and 5.6% (w/v) by S. cerevisiae and E. coli inoculated into cassava waste water hydrolyzed by amylolytic fungi. Control flask yielded 0.03% w/v ethanol. Heat pre-treatment of cassava waste water resulted in the production of 2.61% and 0.72% (w/v) ethanol by S. cerevisiae and E. coli respectively. The study revealed that the isolates had the ability of ethanol production from cassava waste water. Also, it demonstrates that cassava waste water is a suitable substrate which can be harnessed for ethanol production, thus curbing the pollution nuisance it poses in cassava processing areas.
Adesayan, O.A., Oluyemi, K.A., Josiah, S.J., Adesayan, R.A., Shittu, L.A.J.,
Ofusori, D.A., Bakole, M.A and Babalola, G.B. (2008). Ethanol production
by Saccharomyces cerevisiae from cassava peel hydrolysate. International Journal
of Microbiology 5(1): 351-356.
Amutha, R. and Paramasamy, G. (2001).Production of ethanol from liquefied cassava starch using co-immobilized cells of Zymomonas mobilis and Saccharomyces diastaticus. Journal of Bioscience & Bioengineering 92:560-564
Arotupin, D.J. (2007). Evaluation of microorganisms from cassava waste for production of amylase and Cellulase. Research Journal of Microbiology 2(5): 475-480.
AOAC (1990). Association of Official Analytical Chemist. Method of Analysis. 13th
edn. Washington D.C.
Barnet, H.L. and Hunter, B.B (1972). Illustrated genera of imperfect fungi. 3rd edn,
Burges Publishing Company, Minneapolis.
Ergun, M. and Freda, M.S. (2000). Application of a Statistical Technique to the Production of Ethanol from Sugar Beet Molasses by Saccharomyces cerevisiae. Bioresource Technology 73: 251-255.
Fregonesi, A., Moran-Paulo, J., Joekes, I., Augusto, J., Rodrigues, R., Tonella, E and Atthof, K (2007). Continous Fermentation of Sugar cane Syrup Using Immobilized Yeast Cells. Bioresource & Bioengineering. 97:48-52
Irfana, M., Kanawal, M., Siikender, A and Ukram, U (2009). Enhanced production
of ethanol from free and immobilized Saccharomyces cerevisiae under stationary
culture. Pakistani Journal of Botany 41 (2): 821-833.
Moreira, N., Mendes, F., Hogg, T and Vasconceles, M. (2009). Alcohol, esters and
heavy sulphur compounds by pure and mixed cultures of apiculate wine yeast.
Indian Journal of Microbiology 18: 17-25 Nwabueze, T.U. and Ugochinyere, O
(2006).Effect of supplementation of African breadfruit (Treculia Africana) hulls
with organic waste on growth characteristics of Sacchoromyces cerevisiae. African
Journal of Biotechnology 5(16): 1494- 1498.
Obadina, A.O., Oyewolee, O.B., Sanni, L.O. and Abiola, S.S. (2006). Fungal enrichment of cassava peels proteins. African Journal of Biotechnology 5(3): 302-304. Odunfa, S.A. (1987). Saccharification of cassava peels waste for microbial protein. Acta Biotechnology 7(1): 123-129.
Ofuya, C.J. and Nwajuiba, C.J (1990). Microbial degradation and utilization of cassava peels. World Journal of Microbiology & Biotechnology 6: 144-148.
Onabolu, A.O. (1999).Cassava processing in a Nigerian community affected by neuropathy atributed to dietary cyanide exposure. Tropical Science 39: 129-135.
Willaert, R. and A.N. Viktor (2006). Primary beer fermentation by immobilized
yeast – a review on the flavor formation and control strategies. J. Chem. Technol.
Biotechnol. 81: 1353 – 1367.